Office Address

  • 688 Gaoke East Road, Pudong New Area, Shanghai, China.
  • [email protected]
  • +86-21-58386189, 58386176

Products

Social List

quarry dust as fine aggregate in concrete

  • EFFECT OF SULPHURIC ACID ON THE COMPRESSIVE STRENGTH

    This study determines the effect of Sulphuric acid on the compressive strength of concrete with Quarry Dust as partial replacement of fine aggregate at 0 15 25 and 35 . A total of seventy-two (72) 100 mm cubes were cast and cured in water up to 28 days. The Compressive strength test was done on the first 36 cubes at 7 14 and 28 days while the remaining 36 cubes were exposed to 5

  • Research Article Study on Compressive Strength of Quarry

    Research Article Study on Compressive Strength of Quarry Dust as Fine Aggregate in Concrete K.ShyamPrakash 1 andCh.HanumanthaRao 2 Department of Civil Engineering PVP Siddhartha Institute of Technology Kanuru Vijayawada Andhra Pradesh India

  • STUDY OF OPTIMUM COMPRESSIVE STRENGTH OF PALM

    The suitability of palm kernel shell and quarry dust as coarse and fine aggregates in the concrete were investigated. The materials were pretreated which was followed with determination of physical properties of palm kernel shells and quarry dust as aggregates. A mix design following ACI 211 was used for the concrete mix proportion.

  • Effect of Fly Ash on Mortar Mixes with Quarry Dust as Fine

    Numbers of significant results have been reported on the use of quarry dust as partial replacement for fine aggregate. Quarry dust a byproduct from the crushing process during quarrying activities is one of those materials that have recently gained attentions to be used as concreting aggregates especially as fine aggregates.

  • An Experimental Study on Partial Replacement of Fine

    replace fine aggregate in concrete by an alternate material also to some extent or totally without compromising the quality of concrete. Quarry dust has been used for different activities in the construction industry such as building materials road development materials aggregates bricks and tiles. Quarry Dust

  • Partial Replacement of Fine Aggregates with Quarry Dust

    Powder (CPR)/Quarry dust (QD) as fine aggregate in cement concrete replacing natural sand. The study on concrete includes determination of compressive strength and split tensile strength of different grades of concrete. Properties of aggregate affect the durability and performance of concrete so fine aggregate

  • EXPERIMENTAL STUDY ON STRENGTH OF CONCRETE BY

    inhibitors in concrete containing quarry dust as fine aggregate "Journal of Engineering and Applied Sciences vol. 6 no. 11 pp. 124–135 2011. 7 R. P. Nanda A. K. Das and N. Moharana "Stone crusher dust as a fine aggregate in concrete for paving blocks " International Journal of Civil and Structural Engineering vol.

  • ceramic waste as coarse aggregates and quarry dust

    Stone Dust in Concrete Effect on Compressive Strength. Abstract- Stone dust is a waste material obtained from crusher plants. It has potential to be used as partial replacement of cement fine aggregate coarse aggregate and water. At made of Quarry Rock Dust are nearly 10 more than the conventional concrete (Suribabu et al. 2015). In the present

  • Comparing the compressive strength of concrete made with

    Usually Quarry Rock Dust is used in large scale on the highways as a surface finishing material and also used for manufacturing of hollow blocks and lightweight concrete prefabricated Elements. Use of Quarry rock dust as a fine aggregate in concrete draws serious attention of

  • Crushed rock sandAn economical and ecological

    Sep 01 2016 · R. IlangovanStudies on strength and behaviour of concrete by using quarry dust as fine aggregate Proceedings of All India Seminar on Materials and Machines for Construction. New Age International (2000) pp. 99-102

  • Stone crusher dust as a fine aggregate in Concrete for

    Paving block specimens (figure 1) of sizes 0.25mx0.20mx0.05m made of concrete with cement fine aggregate (sand/coarser dust) and coarse aggregate in the ratio (1 2 4) by weight are casted with following replacements of sand. Concrete Paving bock Sand 100 and crusher dust 0 (FC 0)

  • Comparing the compressive strength of concrete made with

    Usually Quarry Rock Dust is used in large scale on the highways as a surface finishing material and also used for manufacturing of hollow blocks and lightweight concrete prefabricated Elements. Use of Quarry rock dust as a fine aggregate in concrete draws serious attention of

  • quarry dust as fine aggregate in concrete

    Quarry Dust As Fine Aggregate In Concrete Pdf Quarry Dust As Fine Aggregate In Concrete Pdf. From the results of experimental investigations conducted it is concluded that the quarry dust can be used as a replacement for fine aggregate it is found that 40 replacement of fine aggregate by quarry dust gives maximum result in strength than normal co.

  • Crushed rock sandAn economical and ecological

    Sep 01 2016 · R. IlangovanStudies on strength and behaviour of concrete by using quarry dust as fine aggregate Proceedings of All India Seminar on Materials and Machines for Construction. New Age International (2000) pp. 99-102

  • Utilization of Stone Dust as Fine Aggregate Replacement in

    stone dust as partial replacement of fine aggregate in concrete. To accomplish this specimen were cast for different replacement level at an interval of 10 percent to determine workability and compressive strength of concrete at different level of fine aggregate with stone dust. The percentage of stone dust was gradually increased in concrete

  • The Utilization of Quarry Dust as Fine Aggregates in Concrete

    quarry dust which is a waste product from quarry as fine aggregates in traditional concrete. During the tenure of the study some physical and engineering properties of quarry dust and sand were determined and compared. The compressive strength of concrete was determined after replacing sand with quarry dust in various ratios.

  • An Experimental Investigation on Properties of Concrete by

    Dec 12 2017 · An Experimental Investigation on Properties of Concrete by Partial Replacement of Cement with GGBS and Fine Aggregate with Quarry Dust Dr. D. V. Prasada Rao C. S. Mallikarjuna In the present study an investigation is made on properties of concrete by partial replacement of Cement with Ground Granulated Blast Furnace Slag (GGBS) and Fine

  • Partial Replacement of Sand with Quarry Dust in Concrete

    -The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as fine aggregates in the production of concretes especially in Concrete. Quarry dust a by-product from the crushing process during quarrying activities is one of such materials.

  • What are the advantages of using quarry dust as fine

    May 22 2017 · The availability of sand at low cost as a fine aggregate in concrete is not suitable and that is the reason to search for an alternative material. Quarry dust satisfies the reason behind the alternative material as a substitute for sand at very low cost. It even causes burden to dump the crus

  • Strength of Concrete with Ceramic Waste and Quarry Dust as

    This research focuses on a study of the strength of concrete with ceramic waste as coarse aggregate and quarry dust as fine aggregate. The sources of ceramic waste and quarry dust are obtained from the industrial in Malaysia. Presently in ceramics industries the production goes as waste which is not under going the recycle process yet. In this study an attempt has been made to find the

  • Experimental Investigation on the Effect of

    The demand of natural sand in the construction industry has increased a lot resulting in the reduction of sources and an increase in price. Thus an increased need to identify a suitable substitute that is eco-friendly and inexpensive quarry dust being extensively used as an alternative to the sand in the production of concrete. In this paper an attempt has been made to determine the

  • Stone crusher dust as a fine aggregate in Concrete for

    Paving block specimens (figure 1) of sizes 0.25mx0.20mx0.05m made of concrete with cement fine aggregate (sand/coarser dust) and coarse aggregate in the ratio (1 2 4) by weight are casted with following replacements of sand. Concrete Paving bock Sand 100 and crusher dust 0 (FC 0)

  • Comparison of physical and mechanical properties of river

    Mar 30 2018 · Feasibility of quarry dust to replace river sand as fine aggregate of concrete. Engineer Journal of the Institution of Engineers Sri Lanka 42(4) 30-37. DOI 10.4038/engineer.v42i4.7031.

  • Partial Replacement of Fine Aggregates with Quarry Dust

    Powder (CPR)/Quarry dust (QD) as fine aggregate in cement concrete replacing natural sand. The study on concrete includes determination of compressive strength and split tensile strength of different grades of concrete. Properties of aggregate affect the durability and performance of concrete so fine aggregate

  • Studies on Fresh and Hardened Properties of Recycled

    Twelve series of mixtures comprising reference concrete with natural aggregate and 100 recycled concrete aggregate with natural fine aggregate replaced with quarry dust ranging from 10 to 100 were prepared for this study. All these mixtures were designed for M30 grade (fc′ = 24 MPa 3480 psi ) of concrete.

  • Strength of Concrete with Ceramic Waste and Quarry Dust as

    This research focuses on a study of the strength of concrete with ceramic waste as coarse aggregate and quarry dust as fine aggregate. The sources of ceramic waste and quarry dust are obtained from the industrial in Malaysia. Presently in ceramics industries the production goes as waste which is not under going the recycle process yet. In this study an attempt has been made to find the

  • STUDY OF OPTIMUM COMPRESSIVE STRENGTH OF PALM

    The suitability of palm kernel shell and quarry dust as coarse and fine aggregates in the concrete were investigated. The materials were pretreated which was followed with determination of physical properties of palm kernel shells and quarry dust as aggregates. A mix design following ACI 211 was used for the concrete mix proportion.

  • Partial Replacement of Fine Aggregates with Quarry Dust

    Powder (CPR)/Quarry dust (QD) as fine aggregate in cement concrete replacing natural sand. The study on concrete includes determination of compressive strength and split tensile strength of different grades of concrete. Properties of aggregate affect the durability and performance of concrete so fine aggregate

  • Partial Replacement of Fine Aggregates with Quarry Dust

    Powder (CPR)/Quarry dust (QD) as fine aggregate in cement concrete replacing natural sand. The study on concrete includes determination of compressive strength and split tensile strength of different grades of concrete. Properties of aggregate affect the durability and performance of concrete so fine aggregate

  • EXPERIMENTAL STUDY ON REPLACEMENT OF FINE

    concrete. The water absorption of Quarry Rock Dust concrete is slightly higher than Conventional Concrete. Joseph O Ukpata et al. (2012) The workability of concrete using lateritic sand and quarry dust as fine aggregates was found to have the same trend with normal concrete. The density of hardened concrete using lateritic sand and quarry dust

  • Different Types Sizes of Aggregate for Concrete

    Aug 11 2018 · 1 FINE AGGREGATE. Fine Aggregates are usually sand or crushed stone that are less than 9.55mm in diameter. When the aggregate is sieved through 4.75mm sieve the aggregate passed through it. Natural sand is generally used as fine aggregate silt stone dust

  • Feasibility of Quarry Dust to Replace River Sand as Fine

    concrete with quarry dust as fine aggregate. Keywords Concrete Fine aggregate Quarry dust River sand Compressive strength Shrinkage Workability. 1. Introduction Concrete is one of the most widely used building materials in construction. It is a composite building material made of

  • The Utilization of Quarry Dust as Fine Aggregates in Concrete

    quarry dust which is a waste product from quarry as fine aggregates in traditional concrete. During the tenure of the study some physical and engineering properties of quarry dust and sand were determined and compared. The compressive strength of concrete was determined after replacing sand with quarry dust in various ratios.

  • Crushed rock sandAn economical and ecological

    Sep 01 2016 · R. IlangovanStudies on strength and behaviour of concrete by using quarry dust as fine aggregate Proceedings of All India Seminar on Materials and Machines for Construction. New Age International (2000) pp. 99-102

  • Use of Quarry Dust to Replace Sand in ConcreteAn

    The particles passing through 4.75mm sieve are called as quarry dust. The quarry dust is used to sprinkle over the newly laid bituminous road as filler between the bitumen and coarse aggregate and manufacturing of hollow blocks. Various physical properties of the concrete materials are tabulated in Table 1. Table 1 Properties of the materials

  • Replacement Of Coarse Aggregate In Concrete Civil Planets

    The workability of concrete is excellent when using plastic waste. Mostly the plastic aggregates were used in road construction work. It is mixed with the asphalt to make the road. Already so many projects have been done in this method. Quarry dust For Partial Replacement The bricks tile other lightweight materials are made from the quarry dust.

  • Partial Replacement of Sand with Quarry Dust in Concrete

    -The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as fine aggregates in the production of concretes especially in Concrete. Quarry dust a by-product from the crushing process during quarrying activities is one of such materials.